What are the responsibilities and job description for the Building Maintenance Technician position at Vanderbilt University?
The Building Maintenance Technician is part of the Vanderbilt University Maintenance and Operations (VUMO) and is a key individual responsible for the ongoing maintenance and repair of a building or area. Building Maintenance Technicians need to have a good knowledge of building skills, including HVAC, plumbing, drywall installation, painting, and general building repair. The position reports directly to a Zone Manager.
VUMO provides facilities support for all construction, renovation, and routine maintenance of University Central space and facilities; housekeeping services for approximately 5.8 million square feet of academic, administrative, residential, and recreational space; grounds care for 330 acres that are a registered arboretum; turf care for athletic fields; and utilities for the University Central and the Medical Center.
VUMO's annual budget exceeds $100 million in operating expenses and includes over 400 employees. Facilities manages major capital project expenditures totaling ~$125 million annually and facility renewal, replacement and large maintenance project expenditures totaling ~$20 million annually.
Duties and Responsibilities
- Change filter in dorm room unit
- Check chilled water pressure in building
- Check Steam pressure at pry station in building
- Check run status on air handling unit of pump
- Check alarm on VFD and condensate pump
- Investigate water leaks
- Change air filters in AHU
- Grease pump/motor bearings
- Check a steam trap for proper operation
- Check/prime AC drain trap
- Assist HAR Tech in pulling motors on equipment
- Assist Tech with condensate pump system repairs
- Clean AHU coils/air intakes
- Change out thermostats
- Check discharge air temps on HVAC equipment
- Clean and organize work areas, including mechanical/electrical rooms’ parts storage areas
- Plunge sink and toilet (snaking)
- Replace shower curtain rods
- Tighten toilet seat
- Replace wax ring on toilet and reset toilet
- Rebuild flush valve
- Use small sewer machine
- Change batteries in auto flush valves
- Use pro-press to install piping and valves
- Change out fire extinguishers (including record keeping)
- Test fire extinguishers (including record keeping)
- Clean out drains
- Caulk sinks and vanities
- Change out toilet tank float/flush assemblies
- Change out water stop valves
- Help w/winterization at Stadium
- Help w/installation of shutoff valves on water mains to each floor of buildings
- Help plumber w/various plumbing/piping repairs
- Assist plumber w/repair or replacement of water heaters
- Minor piping repairs to fix leaks
- Replace ceiling tile
- Replace rubber base
- Replace carpet and carpet squares
- Hang pictures/bulletin/dry erase/chalk boards
- Cut and install small drywall pieces/mud
- Patch holes and nail holes
- Help carpenter lay ceramic floor tile and grout
- Respond to roof leak calls and locate leak
- Change out/install door sweeps
- Install/replace door stops
- Repair tracks on sliding doors
- Minor dorm furniture repairs
- Assist carpenter w/assembling trash cans/benches & setting them
- Repair brackets for wall shelving
- Replace lamps and ballasts in any fixture
- Replace/upgrade fixtures
- Replace receptacles and switches
- Reset small amperage circuit breakers
- Proper handling/disposal of lamps and ballasts
- Organize bulb supply and spent bulb storage locations
- Use Volt-Ohm Meter to check voltage/current
- If trained, use man lift/boom lift/scissor lift and single man lift/bucket truck for various repairs
- String lights and drop cords in tents for special events
- Assemble scaffolding/adjustable ladders to work on various lighting repairs
- Assist electrician on conduit runs/wire pulls
- Hand banners on street light poles
- Set up and monitor personal work order query
- Process daily work order time sheet
- Operate vehicle/golf cart and perform operator level maintenance
Other duties related to classification
Salary : $20 - $125
